公路桥梁板式橡胶支座尺寸表

一、公路桥梁板式橡胶支座规格系列 1、范围

本标准规定了板式橡胶支座的要求、规格系列及选用。

本标准适用于承载力小于5000kN 的公路桥梁用矩形、圆形平板式橡胶支座。 2、规范性引用文件

下列文中的条款通过本标准的引用而成为本标准的条款。凡是注日期的引用文件，其随后所有的修改（不包括勘误的内容）或修订版均不适用于本标准，然而，鼓励根据本标准达成协议的各方研究是否可使用这些文件的最新版本。凡是不注日期的引用文件，其最新版本适用于本标准。 JT/T4 一2004 公路桥梁板式橡胶支座 JTG D60 一2004 公路桥涵设计通用规范

JTG D62 一2004 公路钢筋混凝土及预应力混凝土桥涵设计规范

3、支座要求

一2004的要求.

3 . 1支座产品分类、代号、结构、技术要求、试验方法、检验规则及标志、包装、贮存、运输、安装和养护均应满足JT/T4

3． 2 支座使用阶段平均压应力бC＝10M Pa ( S ＜7时бC＝8M Pa)；橡胶硬度60 ( IRHD ）时，其常温下剪变模量G = 1.OMpa 。剪变模量随温度下降而递增，

当累年最冷月平均温度的平均值O ~-10℃时为寒冷地区，G = 1 . 2MPa ；当低于-10 ℃ 时为严寒地区，G = 1.5MPa ；当低于-25 ℃ 时，G = 2 . 0 MPa 。全国气温分区图见JTG D60 一2004附录B。

3.3支座橡胶弹性体体积模量Eb= 2000 MPa。支座与混凝土接触时，摩擦系数μ= 0 . 3 ，与钢板接触时，摩擦系数μ＝0 . 2 。聚四氟乙烯板与不锈钢板接触（加硅脂）时，μf＝0 . 06 ，当温度低于-25 ℃ 时，μf值增大30 % ，当不加硅脂时，μf应加倍。若有实测资料时，也可按实测资料采用。

3.4 橡胶支座剪切角α 正切值，当不计制动力时，tan α不大于0 .5 ，当计入制动力时，tan α不大于0 .7. 3.5 橡胶支座的计算和验算均应满足JTG D62 一2004的要求。 4、普通板式橡胶支座

4 . 1 普通板式橡胶支座结构示意图见图1 、图2 。

4 . 2 普通板式橡胶支座代号，矩形为GJZ 、圆形为GYZ。其规格系列见表1 ，表中符号意义如下： ιa ×ιb或d -----平面尺寸或直径； Rck-----最大承压力； S -----形状系数； t -----支座总厚度；

△ι1, -----不计制动力时最大位移量； △ι2 -----计人制动力时最大位移量； t e-----橡胶层总厚度； tanθ -----允许转角正切值； RGk -----抗滑最小承压力；

板式橡胶支座产品代号表示方法

GJZ、GYZ板式橡胶支座规格系列选用参数

la×lb（或d） RCK 序S 号 （mm） （KN） t(mm) △l1 △l2 tanθ（θ的单位为rad） RCK(KN) te 温热地区 寒冷地区 严寒温热地区 地区 寒冷地区 严寒地区 t1 t0 (mm(mm) ) 0.01021 GJZ 1 100×150 28 7.5 10.5 20 0.016 5 101 5.48 5 7 15 7 0.009 0.0074 35(53) 0.0130.0111 42(63) 53(79) 5 2 0.0080.0070.00621 GJZ 2 100×200 28 7.5 10.5 20 1 0.00521 5 7 15 7 0.0080.00728 3 GYZ d150 154 7 0.0110.00935 10 14 25 4 12.42 5 17.5 30 3 0.00521 5 7 15 7 0.0080.007GJZ 4 150×150 0.0110.00935 10 14 25 4 42 7 0.008 196 7 28 7.5 10.5 20 5 3 0.006 53(79) 63(95) 79(118) 5 2 0.005 - 2 1 7 0.008 7.5 10.5 20 5 3 41(62) 49(74) 62(930 5 2 0.006 0.005 - 1 1 137 6.11 0.0130.0110.0095 7 15 7 4 1 47(70) 56(84) 70(105) 5 2 0.0140.0120.01012.17.5 30 0.0140.0120.0105 21 5 7 3 15 0.005 2 - 1 - 0.0060.00528 GJZ 5 150×200 266 8.06 35 10 14 25 9 12.42 5 17.5 30 2 0.00528 7.5 10.5 20 7 GJZ 6 150×250 12.42 5 17.5 30 6 0.00528 7.5 10.5 20 2 GJZ 7 150×300 12.42 5 17.5 30 9 0.00535 10 14 25 1 12.42 8 GYZ d200 284 9.5 5 17.5 30 4 5 0.0060.0050.005 73(110) 88(132) 110(165) 5 2 - - 3 3 406 9.44 35 10 14 25 9 6 0.0060.0060.005 105(1580 126(189) 158(236) 5 2 0.005 - 3 9 336 8.84 35 10 14 25 7 6 5 0.0070.0060.00588(131) 105(158) 131(197) 5 2 0.005 - 6 7 4 0.0080.0070.00670(105) 84(126) 105(158) 5 2 7.5 10.5 20 7 7 0.005 0.0110.0090.008 0.0090.0080.0060.0080.0080.0060.0070.0060.00549 15 21 35 7 56 6 6 17.24.5 40 0.0080.0070.0065 9 0.0057 5 35 10 14 25 1 - - 12.42 GJZ 9 200×200 49 15 21 35 361 9.5 5 17.5 30 0.0060.0050.005 4 5 93(140) 0.0070.0060.0057 6 6 112(168) 140(210) 5 2 17.56 5 12.42 5 1GJZ 456 0 200×250 17.56 5 24.5 40 10.6 49 15 21 35 17.5 30 24.5 40 0.0080.0070.0069 0.0050.005 4 0.0060.0050.005 117(175) 4 6 140(210) 175(263) 5 2 - 7 5 0.0070.0060.0055 6 6 0.0060.00530 8 11.2 21 6 1GJZ 551 1 200×300 7.17 41 12 16.8 29 8 4 6 0.005 0.0090.0080.007 140(210) 168(252) 210(315) 8 3 0.0130.0110.00952 16 22.4 37 1 2 3 0.0050.00530 8 11.2 21 9 1GJZ 646 2 200×350 7.62 41 12 16.8 29 9 6 3 1 - 0.0080.0070.006163(245) 196(294) 245(368) 8 3 0.0110.0100.00852 16 22.4 37 8 1 4 0.00530 8 11.2 21 5 1GJZ 741 3 200×400 7.98 41 12 16.8 29 2 0.0080.007 9 0.005187(280) 224(336) 280(420) 8 3 0.005 - 0.0100.0090.00752 16 22.4 37 9 3 8 0.0070.0060.00541 12 16.8 29 3 2 2 0.0090.0080.00652 1GYZ d250 452 4 63 20 28 45 1 4 6 7.5 0.0120.0100.00816 22.4 37 7 3 9 115(172) 137(206) 172(258) 8 3 0.0140.0120.01074 24 33.6 53 6 4 3 0.0070.0060.00541 12 16.8 29 3 2 2 0.0090.0080.00652 1GJZ 576 5 250×250 63 20 28 45 1 4 6 7.5 0.0120.0100.00816 22.4 37 7 3 9 146(219) 175(263) 219(328) 8 3 0.0140.0120.01074 24 33.6 53 6 4 3 0.0060.00541 1GJZ 696 6 250×300 8.21 52 16 22.4 37 3 63 20 28 1 0.0080.0070.006 175(263) 210(315) 263(394) 8 3 12 16.8 29 2 4 0.005 45 0.0140.0080.0071 9 5 0.0120.01074 24 33.6 53 5 0.00541 12 16.8 29 6 0.0070.0060.00552 1GJZ 816 7 250×350 63 20 28 45 3 8.79 0.0090.008 7 0.00616 22.4 37 4 4 4 204(306) 245(368) 306(459) 8 3 0.005 - 7 0.009 0.0110.0090.00874 24 33.6 53 1 0.00541 12 16.8 29 1 0.0060.00552 1GJZ 936 8 250×400 63 20 28 45 5 3 2 9.29 0.0080.0070.00616 22.4 37 8 9 233(350) 280(420) 350(525) 8 3 0.005 - - 6 1 0.0100.0080.00774 24 33.6 53 2 41 12 16.8 29 0.005 8 - 4 - 0.0060.00552 1GJZ 1056 9.71 9 250×450 63 20 28 45 9 8 2 0.0070.0060.006263(394) 315(473) 394(591) 8 3 16 22.4 37 3 5 0.005 0.0090.0080.00774 24 33.6 53 5 2GJZ 1176 10.041 12 16.8 29 0.005 2 - 4 - 292(438) 350(525) 438(656) 8 3 0 250×500 7 52 16 22.4 37 0.006 0.005 - 2 0.0070.0060.00563 20 28 45 4 5 5 0.0080.0070.00674 24 33.6 53 9 8 6 0.0050.00552 16 22.4 37 9 1 - 0.0070.0060.00563 2GYZ d300 661 1 74 24 33.6 53 8 6 4 9.06 0.0080.0070.00620 28 45 4 3 3 165(247) 198(297) 247(371) 8 3 0.0100.0080.00785 28 39.2 61 3 9 5 0.0050.00552 16 22.4 37 9 1 - 0.0070.0060.00563 2GJZ 841 2 300×300 74 24 33.6 53 8 6 4 9.06 0.0080.0070.00620 28 45 4 3 3 210(315) 252(378) 315(473) 8 3 0.0100.0080.00785 28 39.2 61 3 0.00552 2GJZ 986 3 300×350 9.78 63 20 28 45 5 74 6 0.0060.0050.005 245(368) 294(441) 368(551) 8 3 16 22.4 37 2 0.005 - 9 5 24 33.6 53 0.0070.0060.0058 8 7 0.0090.0070.00685 28 39.2 61 1 52 16 22.4 37 0.005 9 - 7 - 0.0050.00563 2GJZ 1131 10.4 4 300×400 74 24 33.6 53 1 2 0.0070.0060.003 280(420) 336(504) 420(630) 8 3 20 28 45 9 1 - 0.0080.0070.00685 28 39.2 61 3 0.00563 20 28 45 5 2GJZ 1276 5 300×450 2 10.974 24 33.6 53 6 7 0.0060.0050.005 315(473) 378(5670 473(709) 8 3 0.005 - 2 1 0.0070.0060.00585 28 39.2 61 7 16.54 5 2GJZ 1421 8.28 6 300×500 27.84 5 16.54 5 2GJZ 1566 8.58 7 300×550 69 22 30.8 49 8 84 6 4 0.0080.0070.006385(578) 462(693) 578(866) 11 4 23.1 38 6 7 38.5 60 7 1 4 69 22 30.8 49 4 1 8 23.1 38 0.007 1 1 7 7 0.0060.0050.0090.0080.006350(525) 420(630) 525(788) 11 4 0.0110.0100.0080.0060.0050.005 27.38.5 60 0.011 0.0090.0085 16.54 5 2GJZ 1711 8.64 8 300×600 27.84 5 63 20 28 38.5 60 5 45 0.005 69 22 30.8 49 4 23.1 38 3 5 0.0060.0054 0.005 4 0.0080.0070.006420(630) 3 1 504(756) 630(945) 11 4 0.0100.0090.0071 - 6 - 0.0050.00574 2GYZ d350 908 9 3 85 28 39.2 61 8 10.60.0060.006 1 0.005224(337) 269(404) 337(505) 8 3 24 33.6 53 9 1 - 0.0070.0060.00596 32 44.8 69 8 63 20 28 45 0.005 8 - 8 - 0.0050.00574 3GJZ 1156 0 350×350 3 85 28 39.2 61 8 10.60.0060.006 1 0.005286(429) 343(515) 429(643) 8 3 24 33.6 53 9 1 - 0.0070.0060.00596 32 44.8 69 8 16.54 5 3GJZ 1326 8.26 1 350×400 27.84 5 38.5 60 1 7 3 69 22 30.8 49 1 9 8 23.1 38 1 2 8 8 0.0060.005 - 0.0080.0060.005327(490) 392(588) 490(735) 11 4 0.0100.0080.0070.0200.0100.00899 33 46.2 71 1 16.54 5 23.1 38 5 0.0070.0060.00569 3GJZ 1496 8.72 2 350×450 84 5 27.38.5 60 2 9 7 0.0090.0070.00622 30.8 49 4 4 3 368(551) 441(662) 551(827) 11 4 0.0050.005 - 4 7 0.0110.00999 33 46.2 71 1 16.54 5 23.1 38 1 0.0060.00569 3GJZ 1666 9.12 3 350×500 84 5 27.38.5 60 6 4 2 0.0080.0070.00622 30.8 49 9 9 408(613) 490(735) 613(919) 11 4 0.005 0.005 - - 5 0.008 0.0100.0080.00799 33 46.2 71 3 16.54 5 0.0060.00569 3GJZ 1836 9.48 4 350×550 84 5 27.38.5 60 1 0.0080.007 9 0.00522 30.8 49 4 6 449(674) 539(809) 674(1011) 11 4 0.005 23.1 38 0.005 - - 9 5 0.0090.0080.00799 33 46.2 71 7 3GJZ 2006 9.8 54 16.23.1 38 0.005 4 - 1 - 490(735) 588(882) 735(1103) 11 4 5 350×600 5 0.0060.00569 22 30.8 49 1 27.84 5 38.5 60 6 6 6 3 0.005 0.0070.0060.0050.0090.0070.00699 33 46.2 71 2 16.54 5 0.0060.00569 3GYZ d400 1195 8.86 6 84 5 27.38.5 60 9 8 7 0.0070.0060.00522 30.8 49 3 4 293(440) 352(528) 440(660) 11 4 0.005 23.1 38 0.005 - - 9 7 0.0090.0080.00699 33 46.2 71 4 16.54 5 0.0060.00569 3GJZ 1521 8.86 7 400×400 84 5 27.38.5 60 9 8 7 0.0070.0060.00522 30.8 49 3 4 373(560) 448(672) 560(840) 11 4 0.005 23.1 38 0.005 - - 1 8 0.0090.0080.00699 33 46.2 71 4 0.00569 3GJZ 1716 8 400×450 84 5 9.4 27.38.5 60 1 2 2 0.0070.0060.00522 30.8 49 7 420(630) 504(756) 630(945) 11 4 0.005 - 1 8 0.0080.0070.00699 33 46.2 71 6 38.114 5 0.00569 22 30.8 49 3 27.84 3GJZ 1911 9.87 9 400×500 99 33 46.2 71 9 38.114 5 69 53.9 82 2 - 0.0090.008 8 - 9 8 0.0060.0070.0060.0055 38.5 60 6 7 467(700) 560(840) 700(1050) 11 4 0.0060.0050.005 0.005 - 53.9 82 0.01 6 3 4 3 0.0080.00722 30.8 49 0.005 27.0.0060.00538.5 60 0.005 2 4 513(770) 616(924) 770(1156) 11 4 4GJZ 2106 10.29 84 5 0 400×550 0.0070.0060.00699 33 46.2 71 4 69 22 30.8 49 0.005 27.4GJZ 2301 1 400×600 7 0.0060.00599 33 46.2 71 0.007 1 69 22 30.8 49 0.005 27.4GJZ 2490 2 400×650 2 0.0060.00599 33 46.2 71 7 8 0.005 11.084 5 38.5 60 6 0.0050.005 - 607(910) 728(1092) 910(1365) 11 4 - 2 - 10.684 5 38.5 60 8 1 5 - 5 - 0.0050.005 - 560(840) 672(1008) 840(1260) 11 4 69 22 30.8 49 0.005 27.0.00538.5 60 5 7 0.006 - - 84 4GYZ d450 1521 3 10 99 0.005 - 0.0050.006 1 0.005371(557) 445(668) 557(835) 11 4 33 46.2 71 9 38.114 5 69 53.9 82 0.008 0.007 9 - - 22 30.8 49 0.005 27.0.00538.5 60 5 7 0.00684 4GJZ 1936 4 450×450 10 99 0.005 - 0.0050.006 1 0.005473(709) 567(851) 709(1063) 11 4 33 46.2 71 9 38.114 5 27.84 5 4GJZ 2156 5 450×500 4 38.114 5 27.84 5 4GJZ 2376 6 450×550 2 38.114 5 4GJZ 2596 8.4 70 11.099 10.599 53.9 82 0.008 0.007 9 0.00538.5 60 3 0.0060.00533 46.2 71 4 5 0.005 525(788) 630(945) 788(1299) 11 4 0.005 - 0.0070.0060.00553.9 82 4 5 5 38.5 60 0.005 - - 0.0050.00533 46.2 71 9 2 - 578(866) 693(1040) 866(1299) 11 4 0.0060.0060.00553.9 82 9 1 2 5 22.31.5 50 0.0060.0050.005 630(945) 756(1134) 945(1418) 15 7 450×600 5 2 4 0.0080.00790 30 42 65 3 37.110 5 22.70 5 4GJZ 2816 8.69 8 450×650 37.110 5 22.70 5 31.5 50 9 1 52.5 80 8 5 1 90 30 42 65 9 8 7 31.5 50 9 1 1024(1536683(1024) 819(1229) ) 15 5 52.5 80 4 0.0050.005 - 0.0100.009 5 2 0.0070.006 0.0070.0060.0050.0090.0080.0070.0050.005 - 0.0070.0060.00590 4GYZ d500 1886 8.17 9 110 5 37.52.5 80 8 4 0.0090.0080.007 30 42 65 9 7 6 458(687) 550(825) 687(1031) 15 5 0.0110.0100.008130 45 63 95 8 22.70 5 31.5 50 9 1 1 5 0.0050.005 - 0.0070.0060.00590 5GJZ 2401 8.17 0 500×500 110 5 37.52.5 80 8 4 0.0090.0080.007 30 42 65 9 7 6 583(875) 700(1050) 875(1313) 15 5 0.0110.0100.008130 45 63 95 8 1 5 22.70 5 31.5 50 0.0050.005 4 0.0070.0060.005 - 90 5GJZ 2646 8.56 1 500×550 110 30 42 65 3 3 2 642(963) 770(1155) 963(1444) 15 5 37.52.5 80 5 0.0090.0070.0061 8 6 0.0100.0090.007130 45 63 95 9 22.70 5 31.5 50 1 0.0060.00590 5GJZ 2891 8.92 2 500×600 110 5 37.52.5 80 5 3 2 0.0080.0070.00630 42 65 8 9 700(1050) 840(1269) ) 0.005 1050(157515 5 0.005 - - 4 9 0.0100.0080.007130 45 63 95 2 22.70 5 0.0060.00590 5GJZ 3136 9.25 3 500×650 110 5 37.52.5 80 0.008 9 0.0090.008130 45 63 95 6 22.5GJZ 3381 9.55 4 500×700 90 30 42 65 0.0060.005 - 70 5 31.5 50 0.005 - - 817(1225) 980(1470) ) 1225(183815 5 3 0.007 8 0.0060.00530 42 65 4 5 758(1138) 910(1365) ) 0.005 1138(170615 5 31.5 50 0.005 - - 8 7 1 37.110 5 52.5 80 6 3 0.0070.0060.0056 6 0.0090.0070.006130 45 63 95 1 9 7 0.0060.00590 30 42 65 1 37.110 5GYZ d550 2290 5 130 45 63 95 1 52.150 5 73.5 0 6 2 7 9 6 9 0.0090.0070.0065 52.5 80 6 6 5 554(832) 665(998) 832(1247) 15 5 2 - 0.0070.0060.005110.0100.0090.0070.0060.00590 30 42 65 1 37.110 5GJZ 2916 6 550×550 130 45 63 95 1 52.150 5 73.5 0 6 0.00590 30 42 65 7 5GJZ 3186 7 550×600 9.4 110 5 37.52.5 80 1 1 2 0.0070.0060.005770(1155) 924(1386) ) 1155(173315 5 0.005 - 2 7 9 6 9 0.0090.0070.0065 52.5 80 6 6 5 706(1059) 847(1271) ) 1059(158815 5 2 - 0.0070.0060.005110.0100.0090.0070.0080.0070.006130 45 63 95 5 3 2 52.150 5 73.5 110.0100.0080.0070 9 0.0056 2 90 30 42 65 3 0.005 - 37.110 5GJZ 3456 9.76 8 550×650 130 45 63 5 52.5 80 0.0060.0050.005 7 9 834(1251) 0.0060.00595 0.008 9 9 ) ) 1001(15021251(187715 5 52.150 5 90 30 37.110 5 5GYZ d600 2734 9.83 9 130 45 63 42 73.5 110.0090.0080.0060 3 1 - 0.00552.5 80 0.006 2 0.0070.0060.00595 2 3 3 660(990) 792(1188) 990(1484) 15 5 - 9 - 65 0.005 52.150 5 90 30 37.110 5 6GJZ 3481 9.83 0 600×600 130 45 63 42 73.5 110.0080.0070.0060 5 3 - 0.00552.5 80 0.006 2 1008(15121260(18930.0070.0060.005840(1260) 95 2 3 3 ) ) 15 5 - 2 - 65 0.005 52.150 5 90 6GJZ 3776 1 600×650 3 110 5 10.237.30 42 73.5 110.0080.0070.0060 5 3 - 2 - 1092(16381365(20480.00552.5 80 7 0.006 - 910(1365) ) ) 15 5 65 0.005 0.0060.005130 45 63 95 8 52.150 5 37.110 5 6GJZ 4071 10.6 130 45 2 600×700 52.150 5 37.110 5 6GJZ 4366 3 600×750 4 52.150 5 37.110 5 0.0050.005130 45 6GYZ d650 3217 4 7 150 5 52.73.5 0 9 110.0060.006 1 0.00510.663 95 9 1 774(1161) 929(1394) ) - 1161(174215 5 52.5 80 0.005 - - 73.5 0 2 3 4 10.9130 45 63 95 1 4 52.5 80 1 0.0060.0050.005 ) ) ) 1050(15751260(18901575(236315 5 73.5 0 5 0.0050.005 - 6 6 63 95 4 6 52.5 80 4 0.0060.0050.005 980(1470) ) ) 1176(17641470(220515 5 73.5 0 9 0.0050.005 - 9 9 9 0.005 110.0070.0060.005110.0070.0060.005110.0070.0060.005120.0070.0060.005170 60 84 5 37.6GJZ 4096 5 650×650 7 130 45 63 95 0.0050.005 - 10.6110 5 52.5 80 0.005 - - 986(1479) ) ) 1183(17751479(221815 5 8 8 9 9 52.150 5 73.5 0 9 110.0061 0.0050.006 1 120.0070.0060.006170 60 84 5 9 8 0.005102 36 50.4 77 0.006 2 0.0070.0060.005125 45 6GJZ 4416 6 650×700 148 54 75.6 3 9 7 5 0.0070.009 1 4 0.005102 36 50.4 77 6 0.006125 45 6GJZ 4736 9.53 7 650×750 148 54 75.6 3 4 3 7 110.0080.0070.005) ) ) 63 95 0.007 1 0.005 1138(17061365(20481706(255918 5 0.005 - 6 9.2 110.0080.0070.006) ) ) 63 95 4 4 4 1062(15931274(19111593(238918 5 - 9 130.010171 63 88.2 130.0090.0080.006171 63 88.2 1 9 0.005102 36 50.4 77 2 6GYZ d700 3739 9.58 125 45 8 63 95 5 6 0.0060.0050.005 898(1347) ) ) 1078(16161347(202018 5 0.005 - 5 6 110.0070.0060.005148 54 75.6 3 8 7 7 130.0090.0070.006171 63 88.2 1 1 0.005102 36 50.4 77 2 0.0060.005125 45 6GJZ 4761 9.58 9 700×700 148 54 75.6 3 8 7 7 110.0070.0060.005) ) ) 63 95 5 6 0.005 1143(17151372(20581715(257318 5 0.005 - 9 6 130.0090.0070.006171 63 88.2 1 1 0.005125 45 63 95 4 110.0060.005148 54 75.6 7GYZ d750 4301 0 8 171 63 88.2 1 6 6 6 130.0070.0060.005) ) ) 10.23 5 6 0.005 1031(15461237(18561546(231918 5 0.005 - 9 6 100.140.0080.0070.006194 72 8 125 45 63 9 6 5 - 4 - 95 0.005 110.005148 54 75.6 3 7GYZ d800 4902 1 7 171 63 88.2 1 4 10.95 0.005 - 1173(17591407(21111759(2639130.0060.0050.005 6 ) ) ) 18 5 100.140.0070.0060.005194 72 8 9 3 4 5 注1:抗滑最小承载力拦中,括号外数字为支座与混凝土接触时的采用值,括号内数字为支座与钢接触时的采用值;其值均为不计汽车制动力的情况.当计入汽 注2:允许转角正切值是沿支座短边方向转动时计算值,若沿长边方向转动应自行计算.

GYZF4、GJZF4四氟滑板式橡胶支座规格系列选用参数

△l3 la×lb Rck t △l4 te tanθ(θ的单位为 RGK(KN) rad) t1 t0 tf (mm) (mm) 序 (或d) 号 S (mm顺桥桥 (KN (mm) ) 0.001023 ±21 GJZF4 100×150 101 5.48 30 ±30 0 ±30 3 20 0.0160 ±15 7 ) 向 向 向 向 横顺桥桥) 横 (mm温 温 热 寒 冷 严 寒 热 寒 冷 严 寒 地 地 区 地 区 地 区 区 地 区 地 (mm (mm (mm区 ) ) ) 0.0070.009 4 53 0.0130.0115 1 63 79 5 2 2 0.0070.00623 GJZF4 100×202 0 30 137 6.11 ±30 0 ±2±30 3 20 0.0131 1 23 15 0.0057 0.005 0.00730 ±23 GYZF4 d150 154 7 37 ±30 0 ±30 3 25 0.0114 7 0.0120.01044 30 0.0143 2 23 196 0 7 30 ±30 0 15 20 0.0057 0.005 1 - 79 3 0.0085 0.0070.006 95 118 5 2 2 ±0.0090.008 62 74 93 5 2 2 20 0.0085 3 0.006 1 - 0.0110.009±15 0.0087 4 1 70 84 105 5 2 2 GJZF4 150×154 ±2±30 ±3 0.00937 25 0.0114 7 0.0120.01044 30 0.0143 2 23 15 0.005 - 0.00530 GJZF4 150×205 0 266 8.06 37 ±30 0 ±2±30 3 25 0.0089 7 0.00944 30 0.0112 6 30 20 0.0057 0.005 - 0.008 4 ±0.0070.006105 126 158 5 2 2 20 0.0067 7 0.005 1 - 0.008 0.0060.005GJZF4 150×256 0 44 336 8.84 37 ±30 0 ±2±30 3 0.0080.00630 0.0096 3 30 20 0.0052 0.005 0.006GJZF4 150×307 0 44 406 9.44 37 ±30 0 ±2±30 3 0.0080.00630 0.0086 3 37 25 0.0051 - 0.00544 8 GYZF4 d200 284 9.5 ±30 0 51 ±2±30 3 0.0060.00535 0.0077 6 6 ±30 0.0064 5 0.005 110 132 165 5 2 2 9 - ±25 0.0069 6 0.005 158 189 236 5 2 2 9 - ±25 0.0077 6 5 131 158 197 5 2 2 0.0070.00658 40 0.0089 7 37 25 0.0051 - 0.00544 GJZF4 200×209 0 361 9.5 51 ±30 0 ±2±30 3 35 0.0077 6 6 ±0.0060.005140 168 210 5 2 2 30 0.0064 5 0.005 5 - 0.0070.00658 40 0.0089 7 44 30 0.0054 0.005 0.0051GJZF4 200×25456 10.6 0 0 58 51 ±30 0 ±2±30 3 0.0060.00540 0.0075 6 0.00532 21 0.0066 6 1GJZF4 200×300 551 7.17 43 ±30 1 0 ±2±30 3 ±29 0.0098 4 0.0110.00954 37 0.0131 2 0.00532 21 0.0059 1 1GJZF4 200×35646 7.62 43 ±30 2 0 0 ±2±30 3 ±29 0.0089 6 3 0.0070.006245 294 368 8 3 2 - 3 0.0080.007 210 252 315 8 3 2 0.005 6 ±35 0.0064 6 0.005 175 210 263 5 2 2 5 - 0.0100.00854 37 0.0118 1 1GJZF4 200×40741 7.98 32 ±30 ±2±30 ±21 0.0055 0.005 4 - 280 336 420 8 3 2 3 0 43 0 3 29 0.0082 0.007 0.0059 0.0090.00754 37 0.0109 3 8 0.0060.00543 29 0.0073 2 2 0.0080.00654 1GYZF4 d250 4 65 452 7.5 ±60 0 ±3±60 3 45 0.0121 4 6 0.0100.008±37 0.0097 3 9 172 206 258 8 3 2 0.0120.01076 53 0.0146 4 3 0.0060.00543 29 0.0073 2 2 0.0080.00654 1GJZF4 250×25576 5 0 65 7.5 ±50 0 ±2±50 3 45 0.0121 4 6 0.0100.008±37 0.0097 3 9 219 263 328 8 3 2 0.0120.01076 53 0.0146 4 0.00543 29 0.0062 4 0.0071GJZF4 250×30696 8.21 6 0 65 54 ±50 0 ±2±50 3 0.0080.00745 0.0104 9 76 53 5 ±37 0.0083 1 0.006 263 315 394 8 3 2 0.005 3 0.0125 0.0100.009 7 43 29 0.0056 0.005 - 0.0060.00554 1GJZF4 250×35816 8.79 7 0 65 ±50 0 ±2±50 3 45 0.0093 0.008 7 0.0090.00876 53 0.0111 6 43 29 0.0051 - 0.00554 1GJZF4 250×40936 9.29 8 0 65 ±50 0 ±2±50 3 45 0.0085 3 2 ±0.0070.006350 420 525 8 3 2 37 0.0068 9 0.005 1 - ±0.006306 368 459 8 3 2 37 0.0074 4 4 0.0080.00776 53 0.0102 8 43 29 0.005 - 0.00554 1GJZF4 250×450 1056 9.71 9 65 ±50 0 ±2±50 3 45 0.0097 8 8 ±0.0060.005394 473 591 8 3 2 37 0.0063 5 0.005 4 - 0.0080.00676 53 0.0095 2 43 29 0.005 - 0.0052GJZF4 250×501176 0 0 7 65 10.054 ±50 0 ±2±50 3 0.0060.00545 0.0074 5 5 ±37 0.006 2 - 438 525 656 8 3 2 9 - 0.0070.00676 53 0.0089 8 0.00554 37 0.0059 1 0.0060.00565 2GYZF4 d300 1 76 661 9.06 ±60 0 ±3±60 3 53 0.0088 6 4 0.0070.006±45 0.0074 3 3 247 297 371 8 3 2 - 6 0.0080.00787 61 0.0103 9 0.00554 37 0.0059 1 0.0060.00565 2GJZF4 300×30841 9.06 2 0 76 ±70 0 ±3±70 3 53 0.0088 6 4 0.0070.006±45 0.0074 3 3 315 378 473 8 3 2 - 5 0.0080.00787 61 0.0103 9 54 37 0.0052 0.005 0.00565 2GJZF4 300×35986 9.78 3 0 76 ±70 0 ±3±70 3 53 0.0078 8 7 ±0.0060.005368 441 551 8 3 2 45 0.0065 6 0.005 5 - 0.0070.00687 61 0.0091 9 54 1131 10.4 4 0 65 ±70 0 37 45 0.005 - 7 - 420 504 630 3 0.0059 0.005 - 8 3 2 2GJZF4 300×40±3±70 ±1 0.0060.00576 53 0.0071 2 3 0.0070.00687 61 0.0083 2 65 45 0.0055 0.005 0.0052GJZF4 300×451276 5 0 2 87 10.976 ±70 0 ±3±70 3 0.0060.00561 0.0077 7 7 ±53 0.0066 7 0.005 473 567 709 8 3 2 1 - 0.0060.00556 38 0.007 1 2GJZF4 300×501421 8.28 71 ±70 6 0 0 ±3±70 3 ±49 0.0094 1 8 1 0.0080.006525 630 788 11 4 2 0.0100.00886 60 0.0117 1 0.00557 38 0.0066 7 2GJZF4 300×551566 8.58 72 ±70 7 0 0 ±3±70 3 ±49 0.0088 6 0.00987 60 0.011 5 0.00557 2GJZF4 300×601711 8.84 8 0 72 ±70 0 ±3±70 3 49 0.0084 3 87 60 1 ±0.0070.006630 756 945 11 4 3 38 0.0063 4 0.005 0.008 4 0.0070.006578 693 866 11 4 3 0.005 4 0.0105 0.0090.0071 65 45 0.005 - 0.00576 2GYZF4 d350 9 908 3 87 10.6±90 0 ±4±90 3 61 0.0068 0.006 ±53 0.0059 1 6 - - 0.005337 404 505 1 0.0060.0058 3 2 98 69 0.0078 8 8 - 65 45 0.005 - 0.00576 3GJZF4 350×351156 0 0 3 87 10.6±90 0 ±4±90 3 ±53 0.0059 1 - 0.005429 515 643 61 0.0068 0.006 1 0.0060.0058 3 2 98 69 0.0078 8 0.0058 56 38 0.0061 2 - 0.0060.00571 3GJZF4 350×401326 8.26 1 0 86 ±90 0 ±4±90 3 60 0.0101 7 3 0.0080.007±49 0.0081 9 8 490 588 735 11 4 2 0.0100.008101 71 0.0121 4 56 3GJZF4 350×451496 8.72 71 ±90 2 0 86 0 ±4±90 3 60 ±49 0.0074 4 3 38 0.0055 0.005 7 - 0.0060.005551 662 827 11 4 2 0.0092 0.0070.0069 0.009101 71 0.0111 5 56 38 0.0051 - 0.00571 3GJZF4 350×501666 9.12 3 0 86 ±90 0 ±4±90 3 60 0.0086 4 ±49 0.0069 9 7 0.008 - 0.005 0.0070.006613 735 919 2 11 4 2 0.0080.007101 71 0.0103 9 57 38 0.005 - 0.00572 3GJZF4 350×551836 9.48 4 0 87 ±90 0 ±4±90 3 60 0.0081 0.007 9 0.0080.007102 71 0.0097 4 57 38 0.005 - 0.00572 3GJZF4 350×602006 9.8 5 0 87 ±90 0 ±4±90 3 60 0.0076 6 6 ±0.0060.005735 882 3 49 0.0061 3 11011 4 2 0.005 1 - ±0.005674 809 1 49 0.0064 6 10111 4 2 0.005 5 - 0.0070.006102 71 0.0092 9 56 3GYZF4 d400 6 1195 8.86 71 ±90 0 ±4±90 3 49 0.0063 4 ±0.0050.005 440 528 660 11 4 2 38 0.005 - 7 - 0.0060.00586 60 0.0079 8 7 0.0080.006101 71 0.0094 1 56 38 0.005 - 0.00571 3GJZF4 400×401521 8.86 7 0 86 ±90 0 ±4±90 3 60 0.0079 8 7 ±0.0060.005560 672 840 11 4 2 49 0.0063 4 0.005 8 - 0.0080.006101 71 0.0094 1 71 49 0.0057 0.005 8 - 0.0060.00586 3GJZF4 400×451716 9.4 8 0 101 ±90 0 ±4±90 3 71 0.0086 4 3 ±0.0070.006630 756 945 11 4 2 60 0.0071 2 2 0.0080.007116 82 0.01 6 71 49 0.0053 0.005 0.00586 3GJZF4 400×500 1911 9.87 9 101 ±90 0 ±4±90 3 71 0.0079 9 8 0.006116 82 0.0092 0.008 8 72 ±90 9 87 0 49 60 0.005 - - 770 924 3 0.0062 0.0050.005 5 ±0.0060.005700 840 0 60 0.0066 7 10511 4 2 0.005 3 - 4GJZF4 400×552106 0 0 10.2±4±90 ±11511 4 3 4 0.0060.005102 71 0.0074 5 72 49 0.005 0.005 - 0.0054GJZF4 400×602301 1 0 7 102 10.687 ±90 0 ±4±90 3 0.0060.00571 0.007 1 72 4GJZF4 400×652490 2 0 2 102 11.087 ±90 0 ±4±90 3 71 0.0067 8 71 86 4GYZF4 d450 3 1521 10 101 0 0 0 3 ±11±4±11±71 0.0069 0.006 1 0.005116 82 0.008 0.007 9 71 86 4GJZF4 450×651936 10 4 0 101 0 0 0 3 ±11±4±11±71 0.0069 0.006 1 0.005116 82 0.008 0.007 9 86 ±11±4±11±101 0 0 0 3 60 71 0.0053 0.005 - 788 945 4 0.0064 0.0050.005 1 49 60 0.005 - - - 0.005709 851 3 10611 4 2 49 60 0.005 - - - 0.005557 668 835 11 4 2 0.0050.005 ±49 60 0.005 - 2 - - 910 2 5 10913611 4 3 ±60 0.0058 1 - 840 8 0 10012611 4 3 5 - 0.0056 0.005 0.0057 0.005 0.0057 0.005 4GJZF4 450×502156 5 0 10.511811 4 2 5 0.0060.005116 82 0.0074 5 87 60 0.005 - 0.0054GJZF4 450×552376 6 0 2 117 0 0 0 3 0.0060.00582 0.0069 1 0.00573 50 0.0062 4 4GJZF4 450×602596 8.4 7 0 93 0 0 0 3 ±11±4±11±65 0.0083 2 0.007113 80 0.0104 0.009 5 0.00573 50 0.0059 1 4GJZF4 450×650 2816 8.69 93 8 0 0 0 3 ±11±4±11±65 0.0079 8 7 4 9 6 0.0060.00510212215315 5 3 - 0.0070.006 945 4 8 11314115 5 3 0.005 2 11.0102 ±11±4±11±71 0.0059 2 - 866 0 9 10412911 4 3 5 - 0.0080.007113 80 0.0098 5 0.00572 50 0.0059 1 0.0060.0054GYZF4 d500 9 112 1886 8.17 0 0 0 3 0.00880 0.0098 4 132 95 0.0118 0.0100.0080.007 92 ±11±4±11±65 0.0079 7 6 687 825 1 10315 5 2 - 1 1 0.00572 50 0.0059 1 5 - 0.0060.00592 5GJZF4 500×502401 8.17 0 0 112 0 0 0 3 80 0.0098 4 0.0100.008132 95 0.0118 1 73 50 0.0054 0.005 5 - 0.0080.007 ±13±4±13±65 0.0079 7 6 875 0 3 10513115 5 2 0.0060.00593 5GJZF4 500×552646 8.56 1 0 113 0 0 0 3 80 0.0091 8 6 ±13±4±13±0.0070.006963 5 4 65 0.0073 3 2 11514415 5 3 0.0090.007133 95 0.0109 4 73 50 0.0051 - 0.00593 5GJZF4 500×602891 8.92 2 0 113 0 0 0 3 80 0.0085 3 2 ±13±4±13±0.0070.0060 0 5 65 0.0068 9 10512615715 5 3 0.005 9 - 0.0080.007133 95 0.0102 8 73 5GJZF4 500×653136 9.25 93 3 0 113 0 0 0 3 80 ±13±4±13±65 0.0064 5 0.008 0.0060.00550 0.005 - 0.0050.005 8 5 6 7 - 11313617015 5 3 9 0.008133 95 0.0096 3 73 50 0.005 - 0.00593 5GJZF4 500×703381 9.55 4 0 113 0 0 0 3 80 0.0076 6 ±13±4±13±65 0.0061 3 8 0.007 - - 1221471830.0060.0055 6 0 8 15 5 3 0.0070.006133 95 0.0091 9 0.00593 65 0.0061 2 0.0060.005113 5GYZF4 d550 5 133 2290 9 0 0 0 3 95 0.0091 9 6 0.0070.006±13±4±13±80 0.0076 6 5 832 998 7 12415 5 3 - 7 0.0090.007153 110 0.0106 2 0.00593 65 0.0061 2 0.0060.005113 5GJZF4 550×552916 6 0 133 9 0 0 0 3 95 0.0091 9 6 0.0070.0069 1 8 ±13±4±13±80 0.0076 6 5 10512715815 5 3 - 7 0.0090.007153 110 0.0106 2 5GJZF4 550×603186 9.4 93 ±13±4±13±65 0.0057 0.005 7 - 11513817315 5 3 7 0 113 0 0 0 3 80 0.0071 0.0060.0051 2 5 6 3 0.0070.006133 95 0.0085 3 2 0.0080.007153 110 0.0109 6 93 65 0.0053 0.005 0.005113 5GJZF4 550×653456 9.76 8 0 133 0 0 0 3 95 0.008 9 9 ±13±4±13±0.0060.0051 2 7 80 0.0067 8 12515018715 5 3 0.005 2 - 0.0080.006153 110 0.0093 1 93 65 0.005 - 0.005113 5GYZF4 d600 9 2734 9.83 133 0 0 0 3 95 0.0072 3 3 ±13±4±13±0.0060.005990 8 4 80 0.006 2 11814815 5 3 - 9 - 0.0070.006153 110 0.0085 3 93 65 0.005 - 0.005113 6GJZF4 600×603481 9.83 0 0 133 0 0 0 3 95 0.0072 3 3 ±13±4±13±0.0060.0050 2 0 80 0.006 2 12615118915 5 3 - 2 - 0.0070.006153 110 0.0085 3 2 93 113 6GJZF4 600×653776 1 0 3 10.2133 0 0 0 3 ±13±4±13±65 80 0.005 - - - 1361682040.005 15 5 3 8 5 3 0.0057 0.005 0.00595 0.0068 9 0.0060.005153 110 0.0079 9 113 80 0.0054 0.005 0.0056GJZF4 600×704071 10.5 2 0 153 0 0 0 3 0.0060.005110 0.0075 6 113 80 0.0051 0.005 0.0056GJZF4 600×754368 3 0 4 153 0 0 0 3 0.0060.005110 0.0072 3 113 80 0.005 - 0.005133 6GYZF4 d650 4 3217 7 153 0 0 0 3 110 0.0069 0.006 1 0.0060.005173 125 0.0078 8 113 6GJZF4 650×654096 5 0 7 153 10.6133 0 0 0 3 ±15±4±15±95 0.0059 1 110 0.0069 0.006 0.00580 0.005 - 0.005 - 9 5 8 9 - 14717722115 5 3 10.6±15±4±15±0.0051 4 4 95 0.0059 1 11613917215 5 3 - 4 - 10.9133 ±15±4±15±95 0.0061 4 5 0 3 0.005 15718923615 5 3 6 - 133 ±15±4±15±95 0.0064 6 0 4 5 0.005 14717622015 5 3 9 - 1 0.0060.005173 125 0.0078 8 0.005105 77 0.006 2 0.0060.005128 6GJZF4 650×704416 9.2 6 0 151 0 0 0 3 113 0.0089 7 5 0.007174 131 0.0104 0.009 6 105 77 0.0056 0.005 - 0.0070.0063 1 9 ±15±4±15±95 0.0074 4 4 15919123818 5 3 - 9 0.0060.005128 6GJZF4 650×754736 9.53 7 0 151 0 ±15 0 3 113 0.0084 3 2 ±15±0.0070.0066 8 9 95 0.007 1 1 17020425518 5 3 0.0080.007174 131 0.0099 5 105 77 0.0052 0.005 0.005128 6GYZF4 d700 8 3739 9.58 151 0 0 0 3 113 0.0078 7 7 ±15±4±15±0.0060.0057 6 0 95 0.0065 6 13416120218 5 3 0.005 2 - 0.0070.006174 131 0.0091 9 105 ±15±4±15±4761 9.58 9 0 128 0 0 0 3 95 0.0065 0.0050.005 5 8 3 77 0.0052 0.005 6 - 6GJZF4 700×7017120525718 5 3 6 0.0060.005151 113 0.0078 7 7 0.0070.006174 131 0.0091 9 128 95 0.0054 0.005 0.005151 7GYZF4 d750 0 4301 6 174 0 0 0 3 131 0.0076 6 6 10.2±18±4±18±0.0060.0056 6 9 113 0.0065 6 15418523118 5 3 0.005 6 - 0.0070.006197 149 0.0086 5 128 151 7GYZF4 d800 1 4902 7 10.9174 0 0 0 3 ±18±4±18±131 0.0064 6 0.0060.005197 149 0.0073 4 5 95 0.005 - 4 - - 1752112630.005 9 1 9 18 5 3 113 0.0055 0.005 0.005注1:抗滑最小承载力拦中的数字为支座与钢材接角时的采用数值;其均值为不计汽车制动力的情况当记入汽车制动力时,另行计算. 注2:允许转角正切值是沿支座短边方向转动时计算值,若沿长边转动应自行计算.